802201
1
Zoom out
Zoom in
Previous page
1/4
Next page
Operating instructions
Air Top 00 ST35
Air Top 5000 ST
Servicing and safety instructions
Servicing and safety instructions
1. The heater has been type-tested and approved in
accordance with EC Directives 72/245/EEC (EMC) and 2001/56/EC (heater) with the
following EC permit numbers:
e1*72/255*95/54*1221*00
e1*2001/56*0021*00
2. The year in which the heater was used for the first time must be permanently displayed
on the factory plate be deleting the inapplicable years from the plate.
To install the Air Top 3500 ST D / 5000 ST D heater in hazchem vehicles, the
requirements of ADR must be satisfied in addition to the Road Traffic Registration
Directive.
4. Claims can only be made if it can be verified that the claimant has complied with the
servicing and safety instructions.
7. The heater must be checked by an expert at the latest at the start of the cold weather
period.
8. In the event of long-lasting heavy smoke development, unusual combustion noises or a
smell of fuel or if the heater suffers continuous fault cut-outs with error messages (flashing
code), it must be put out of service be removing the fuse and must not be reused until it
has been nspected by Webasto-trained personnel.
Air Top 3500 ST / 5000 ST
NOTE:
The provisions of these Directives are binding within the territory governed by EU
Directive 70/156/EEC and should similarly be observed in countries without specific
regulations.
3. The heaters are not designed for heating hazardous substance transport
compartments.
5. The heater must be switched off at filling stations and tank farms as a result of
the risk of explosion.
6. The heater may not be operated in enclosed spaces (such as garages) as a result
of the risk of poisoning and asphyxiation, even if a timer or Telestart remote is
used.
9. Wherever inflammable vapours or dust may form (for example in the vicinity of
fuel, carbon, wood dust or cereal stores or the like), the heater must be switched
off as a result of the risk of explosion.
Air Top
e1*2001/56*0020*00
Air Top
10. The heat transfer unit on air heaters is exposed to very high thermal stress and
must be replaced by a genuine Webasto spare part ten years after it is used for the
first time.
If exhaust lines pass through areas used by personnel, they must also be replaced
by genuine spare parts after ten years.
11. The fuel specified by the vehicle manufacturer is suitable for combusting in
Air Top 3500 ST B / Air Top 5000 ST B. Both leaded and unleaded fuel may be used.
The diesel fuel specified by the vehicle manufacturer must be used for the Air Top 3500
ST D / Air Top 5000 ST D heater (diesel). Class EL heating oil (not L heating oil) may also
be used as long as it complies with the normal quality available on the German market
pursuant to DIN 51603.
The Air Top 3500 ST D / Air Top 5000 ST D heater is also licensed for use with PME
(bio-diesel), which complies with DIN EN 14214.
We know of no negative influences due to additives.
If fuel is extracted from the vehicle's tank, follow the additive instructions issued by the
vehicle manufacturer.
If you change to low-temperature fuel, the heater must be operated for approx.
15 minutes so that the fuel system is filled with the new fuel.
12. The temperature in the area around the heater must not exceed 85 °C (storage
temperature). If the temperature exceeds this level there is a risk of permanent damage to
the electronics systems.
13. Failure to follow the installation instructions and the notes contained therein will lead
to all liability being refused by Webasto. The same applies if repairs are carried out
incorrectly or with the use of parts other than genuine spare parts. This will result in the
invalidation of the type approval for the heater and therefore of its homologation / EC type
licence.
14. Keep the hot air inlet and hot air outlet free of dirt and foreign bodies.
Contaminated or blocked hot air lines may cause overheating and thus result in the
overheating cut-out tripping.
15. To prevent mechanical parts seizing, the heater should be operated for approx.
10 minutes every four weeks.
16. Do not stand on the heater and do not place any heavy items on the heater or throw
items at the heater.
17. Do not place any items of clothing, textiles or similar materials over the heater or in
front of the hot air inlet and the hot air outlet.
18. The current of hot air in the heater must not be restricted or blocked by highly
inflammable substances or materials such as rags, cleaning wool, etc.
19. The heater must not be cleaned with a high pressure cleaner.
Ident-Nr. 90 103 14A 5/0404
Webasto Thermosysteme International GmbH
Postfach 80 - D-82132 Stockdorf -
http://www.webasto.de
1


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Webasto Air Top 3500 ST at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Webasto Air Top 3500 ST in the language / languages: English as an attachment in your email.

The manual is 0.05 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

Others manual(s) of Webasto Air Top 3500 ST

Webasto Air Top 3500 ST User Manual - German - 4 pages

Webasto Air Top 3500 ST User Manual - Dutch - 4 pages

Webasto Air Top 3500 ST User Manual - French - 4 pages

Webasto Air Top 3500 ST User Manual - Italian - 4 pages

Webasto Air Top 3500 ST User Manual - Spanish - 4 pages


The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info