517160
27
Zoom out
Zoom in
Previous page
1/32
Next page
27
§ CHECKING THE SPARK PLUG §
Ÿ The electrodes too dirty or excessive air gap will cause hard or fail starting,
so it will be inspect and adjusted periodically.
Ÿ Remove the cap of spark plug cable (remove the spark plug using the
spark plug wrench in the tool kit.
Ÿ Check the electrode if it is dirty or fouled by carbon deposits.
Ÿ Remove the carbon deposits on the electrode with steel wire, and clean the
spark plug with gasoline, then, wipe dry with a rag.
Ÿ Check the electrode, and adjust its gap to 0.6~0.7 mm. (Check it with a
feeler gauge)
Ÿ Hand tight the spark plug as far as it can go and then tighten it another
1/2~3/4 turns with a wrench.
§ CHECKING THE AIR CLEANER §
If air cleaner is clogged by dust, engine performance and fuel
economy will be affected, so, its important to do periodic
maintenance.
1. Remove the left side cover.
2. Remove the air cleaner cover by removing the three screws.
3. Remove the air cleaner element. Wash the element in clean
solvent and wrap it in dry cloth to try thoroughly.
4. Soak the element in clean gear oil (SAE 30W) then squeeze
out excess oil and install it back.
Procedures for cleaning air cleaner element:
Gasoline or low flash point solvents are highly flammable and
must not be used to clean the element.
Dont keep too much oil in the element, or the engine performance
will be affected.
1.clean. 2.squeeze dry. 3.soak in engine oil. 4.squeeze dry
CAUTION:
Ÿ Dust deposit is one of the major causes of reducing output horsepower and increasing fuel
consumption.
Ÿ Change the air cleaner element or clean it more frequently to prolong the engines service life if
the motorcycle is driven on dusty roads very often.
Ÿ If air cleaner is installed improperly, dust will be absorbed into cylinders, which may cause a
premature wear and reducing output power and engine life.
Ÿ Be careful not to soak the air cleaner when washing the motorcycle. Otherwise, it will cause
engine hard to start.
Ÿ Water enters the air cleaner will cause the engine fails to start ,so do not allow water to enter
the air cleaner when washing the motorcycle.
WARNING:
The engine is very hot after running. Pay attention not to get burned.
? Use only spark plugs suitable for the engine specifications of this motorcycle recommended by
the manufacturer. (Refer to specifications.)
0.6~0.7 mm
27


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Sym X-WOLF at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Sym X-WOLF in the language / languages: English as an attachment in your email.

The manual is 1,77 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info