686279
34
Zoom out
Zoom in
Previous page
1/194
Next page
X8 MIG WELDER 2.3 Installation
2.
Pull the front panel outwards from the lower edge.
3.
Remove the lower left cover from the rear of the power source.
4.
Push the cooler inside the power source from the opening in the front.
Note:
Do not use force, but make sure the connectors on the cooler and the power source are
properly connected.
5.
Fill the coolant container with applicable coolant solution. For more information, see Filling cooler on
page 103.
6.
Attach the two screws in the front panel of the power source.
2.3.2.4 Installing or replacing mains cable
The power source is supplied with a 5-meter mains cable without a plug installed.
Warning:
The mains cable must be installed by an authorized electrician.
For high voltage versions, install the 6 mm
2
cable. For multi-voltage versions, install the 16 mm
2
cable.
The mains cable includes the following wires:
1. Brown: L1
2. Black: L2
3. Grey: L3
4. Yellow-green: Protective earth
2.3.3 Wire Feeder installation
This chapter describes the wire feeder installation.
For wire feeder cable connections, see Installing interconnection cable. For information on operating the
wire feeder, see Wire feeder control panel on page 96.
Caution:
Welding quality and efficiency are greatly dependent on the consumable parts used on the wire
line. These include the wire guide tubes, feed rolls, wire liners, gas nozzles and contact tips. Always
ensure that you are using the correct consumable parts suitable for the filler wire size and material.
For more information, visit Kemppi consumable kit selection site at kitselect.kemppi.com.
2.3.3.1 Installing wire feeder
The installation of the Wire Feeder Rotating Plate and Double Wire Feeder Rotating Plate is identical, as is
installing one or two wire feeders.
Install the wire feeder on the power source with a Wire Feeder Rotating Plate. To install two wire feeders, use
a Double Wire Feeder Rotating Plate.
Note: To set up the system for double wire feeder configuration, you need certain assembly parts.
For more information, see Double wire feeder assembly parts.
Proceed as follows:
OPERATING MANUAL | EN 34
©
KEMPPI | 2018-09-28
34


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Kemppi X8 MIG Welder at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Kemppi X8 MIG Welder in the language / languages: English as an attachment in your email.

The manual is 32,66 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

Others manual(s) of Kemppi X8 MIG Welder

Kemppi X8 MIG Welder User Manual - German - 198 pages

Kemppi X8 MIG Welder User Manual - Dutch - 196 pages


The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info