682625
29
Zoom out
Zoom in
Previous page
1/32
Next page
``
29
CHAPTER 9 TROUBLESHOOTING AND REPAIR
The following table provides troubleshooting and repair instructions for problems that may
be encountered when operating the Breeze C. as well as the best way to correct the
problem. The table contains three columns:
Symptom
Probable Cause
Remedy
The problem you are
experiencing
The most likely causes, in order of
probability (most likely first)
Recommended action to
correct each probable cause
Remember: you can contact your dealer at any time for further professional support.
Remark
:
v For troubleshooting repairs, the only tools needed are regular and Philips
screwdrivers to open the rear lights covers, to replace the bulbs if burnt.
v Replacement parts:
· Tyres and tubes are: 4.10/3.506" (all models)
· Headlight bulb: 24V/25W
· Rear light bulb: contact your authorized dealer
No.
Symptom
Probable Causes
Remedy
1
Flat tyre and unstable driving.
ü Low air pressure
ü Puncture
ü Pump tyre to normal pressure
ü Repair tyre
2
The LEDs flash and the
vehicle does not move.
ü (identified by the fault
code)
ü Call for technical support
3
Handbrake is fully engaged
but the vehicle does not stop.
ü Loose handbrake
mechanism
ü Tighten the brake cable
4
When throttle control lever is
rel
eased
on a level surface,
the
Breeze C takes l
onger
than 3 meters to stop.
ü Controller is faulty or
out of adjustment
ü Call for technical support
5
Key switch is turned ON but
the ON light does not come
on.
ü Main fuse (2.1a in
Fig. 1) popped
ü Electrical fault
ü Reset fuse
Note:
Do not reset fuse more than
twice.
If the symptom still recurs, call your
authorized dealer for support.
6
Breeze C does not move
when you squeeze the
throttle control lever
.
ü Key switch is OFF
ü
Charger is connected
to charging socket
ü Handbrake is on
ü Control system failure
ü Turn key switch ON
ü Disconnect charger
ü Take off handbrake
ü Call for technical support
7
Intermittent drive.
ü Battery capacity is low
ü Faulty connections
ü Faulty battery
ü Charge batteries for at least 18 hours
ü Remove battery cover and check
battery connection. If ter
minals are
corroded, clean them with a damp,
clean cloth
ü
If red LEDs are still on, contact your
dealer for a replacement battery
8
Right or left indicator light is
inoperative.
ü Faulty LED light board
ü Replace LED board
9
Headlight or rear light not lit.
ü Burnt out bulb
ü Replace bulb
10
When driving uphill or
carrying heavy loads
,
speed
reduces gradually (but
scooter still moves).
ü Controller became
overheated
ü Stop driving and let controller cool
29


Need help? Post your question in this forum.

Forumrules


Report abuse

Libble takes abuse of its services very seriously. We're committed to dealing with such abuse according to the laws in your country of residence. When you submit a report, we'll investigate it and take the appropriate action. We'll get back to you only if we require additional details or have more information to share.

Product:

For example, Anti-Semitic content, racist content, or material that could result in a violent physical act.

For example, a credit card number, a personal identification number, or an unlisted home address. Note that email addresses and full names are not considered private information.

Forumrules

To achieve meaningful questions, we apply the following rules:

Register

Register getting emails for Afikim Breeze C4 at:


You will receive an email to register for one or both of the options.


Get your user manual by e-mail

Enter your email address to receive the manual of Afikim Breeze C4 in the language / languages: English as an attachment in your email.

The manual is 5,33 mb in size.

 

You will receive the manual in your email within minutes. If you have not received an email, then probably have entered the wrong email address or your mailbox is too full. In addition, it may be that your ISP may have a maximum size for emails to receive.

Others manual(s) of Afikim Breeze C4

Afikim Breeze C4 User Manual - Dutch - 34 pages


The manual is sent by email. Check your email

If you have not received an email with the manual within fifteen minutes, it may be that you have a entered a wrong email address or that your ISP has set a maximum size to receive email that is smaller than the size of the manual.

The email address you have provided is not correct.

Please check the email address and correct it.

Your question is posted on this page

Would you like to receive an email when new answers and questions are posted? Please enter your email address.



Info